| Home | Product Line | MSDS | Photos | Contact Us |
**CLICK HERE FOR A PRINTABLE VERSION OF THIS DOCUMENT**
MATERIAL SAFETY DATA SHEET
(Conforms to 29CFR 1910 1200 - OSHA Hazard Communications
Standard)
SECTION I: PRODUCT IDENTIFICATION
| PRODUCT NAME: | ENRUST RUST CONVERTER |
| MANUFACTURER: | NAPASCO,
INC 213 MAIN PROJECT ROAD SCHRIEVER, LA 70395 |
| EMERGENCY NUMBER: | 1 800 255 3924 (CHEM TEL) |
| INFORMATION NUMBER: | 1 800 325 3407 |
| CHEMICAL FAMILY: | CHEMICAL RUST TREATMENT |
SECTION II: HAZARDOUS INGREDIENTS
| Substance | Approx. % | OSHA | ACGIH |
CARCINOGENICITY
|
CAS | ||
| PEL | TLV | NPT | IARC | OSHA | NO. | ||
| Tannic Acid | <3.00 | 10ppm | 10ppm | Y | Y | N | 1401-55-4 |
| Oxalic Acid | <1.00 | 1ppm | 1ppm | N | N | N | 144-62-7 |
| Ethylene Glycol | <5.00 | 50ppm | 50ppm | N | N | N | 107-21-1 |
| 2-(2-Ethoxyethox) ethanol | <5.00 | N/A | N/A | N | N | N | 111-90-0 |
|
SECTION III: PHYSICAL DATA Boiling Point: 210-220 degrees (F) Vapor Pressure: (mm Hg) Not Det Vapor Density (air=1): <1.0 Solubility in Water: Soluble Appearance and Odor: White milky liquid, bland odor Specific Gravity: 1.040 %Volatile (Volume %): 55-65 Evaporation Rate (water=1) -1 pH: 1.5-2.0 |
SECTION IV: FIRE AND EXPLOSIVE HAZARD DATA Flash Point (F): None Flammable Limits in air (volume %) (test method): Closed Cup Upper: N/A Lower: N/A Extinguishing media: Water, Foam, Carbon Dioxide, Dry Chemical
Unusual Fire and Explosion Hazard: None |
SECTION V: REACTIVITY DATA
Stability: Stable
Incompatibility: Oxidizing Agents
Hazardous polymerization: Will not occur.
Hazardous decomposition products: Thermal Decomposition may
produce oxides of carbon
SECTION VI: HEALTH HAZARD DATA
Threshold limit value: Not Established
Primary Route(s) of exposure:
EYES: Severe Irritation.
INGESTION: Gastrointestinal irritation, Nausea, Diarrhea.
SKIN: Prolonged contact can lead to mild irritation, formation of dark colored
stains.
Emergency and First Aid Procedures:
EYES: Flush with plenty of cool water for at least 15 minutes. If irritation
persists, obtain medical attention.
INGESTION: Give affected person several glasses of water and induce vomiting,
obtain medical attention. Never give anything by mouth to an unconscious person.
SKIN: Remove contaminated clothing and launder before re-use. Wash skin thoroughly
with soap and water
SECTION VII: SPILL OR LEAK PROTECTION
Steps to be taken if material is released or spilled:
Soak up on absorbent material and place in a properly labeled closed container
for disposal.
Waste Disposal Method: Consult local environmental authorities.
SECTION VIII: SPECIAL PROTECTION INFORMATION
Respiratory protection: Use with adequate ventilation.
Ventilation: Local exhaust Recommended
Mechanical: Not Required
Protective Gloves: Rubber Gloves
Eye Protection: Chemical
Goggles
Other protective equipment: Emergency shower and eye wash station.
SECTION IX: SPECIAL PROTECTION
Precautions to be taken in handling and storage: Store in a cool dry place. Keep container closed tightly when not in use. Keep from freezing. Keep out of reach of children.
HAZARD RATING SYSTEM
|
NFPA 704* Health 2 |
HMIS*** Health 1 |
Key: 0=Insignificant |
*National Fire Protection Association rating identifies the
severity of hazards of material during fire emergency (i.e., 'on fire')
***Hazardous Materials Identification system, National Paint and Coating Assn.
Rating applies to product 'as packaged. (i.e. ambient temp,)
USER RESPONSIBILITY
This bulletin cannot cover all possible situations which the user may experience during use. Each aspect of your operation should be examined to determined if, or where, additional precautions may be necessary. All health and Safety information contained in this bulletin should be provided to your employees and customers. It is your responsibility to use this information to develop appropriate work and practice guidelines and employee instructional programs for your operation.
DISCLAIMER OF LIABILITY
As the conditions or methods of use are beyond our control, we do not assume any responsibility and expressly disclaim any liability for any use of this material. Information contained herein is believed to be true and accurate but all statements or suggestions are made without warranty, expressed or implied, regarding accuracy of the information, the hazards connected with the use of the material or the results to be obtained from the use thereof.